# Air Conditioner Repair and Replacement: Cost, Hours and Process in Hacienda Heights Air conditioner repair and replacement covers rooftop and basement air units: capacitors, fan motors, control boards, thermostats, shroud and gasket work, and full unit replacement. Any operation that recovers or charges refrigerant requires EPA Section 608 certification and cannot legally be performed without it. ## Specifications - Price band: $750 to $4,500 - Shop hours: 2 to 14 hours - Turnaround tier: Systems and electrical - Insurance billable: yes - Certification required: epa608 - Parts lead time: Capacitors, motors and boards 3 to 10 business days. Complete units 7 to 25 business days. - OEM brands: Dometic, Coleman-Mach, Furrion, Truma, Atwood ## This work is certification gated, and here is exactly why Anything that opens the refrigerant circuit, recovers refrigerant or adds refrigerant requires EPA Section 608 certification. That is federal law, not a shop policy and not a preference. An uncertified technician performing it is violating the law and, incidentally, venting refrigerant into the atmosphere, which is the reason the rule exists. It is worth understanding what this means for rooftop RV units specifically. Almost all of them are sealed systems with no service ports. They are not designed to be recharged in the field, and there is nowhere to connect a gauge set. So when a shop or a technician tells you they will recharge your rooftop unit, either they are installing ports into a sealed system, or they are describing something they are not going to do. The practical consequence is that a rooftop unit that has genuinely lost its charge is replaced rather than recharged. That is not a shop upsell. It is the design of the equipment, and knowing it in advance is the difference between an informed decision and a surprise. ## What actually fails, in order of frequency The run capacitor is first by a wide margin. It is an inexpensive part that degrades in heat, and a coach roof in the San Gabriel Valley summer is about the harshest capacitor environment there is. The symptom is a compressor that hums and will not start, or a unit that trips a breaker a few seconds after trying. Second is the fan motor, either the condenser fan on top or the blower. A seized or dragging motor produces a unit that cools poorly, ices up, or overheats and cuts out. Third is the control board or the thermostat, which on modern units with ducted multi zone controls is a real category. Fourth, and this is the one owners do not expect, is airflow. A filter that has not been cleaned, a crushed duct, a return path blocked by an interior modification, or a shroud with a broken vane all produce a unit that is mechanically healthy and does not cool. Icing is very often an airflow symptom rather than a refrigerant symptom. - Run capacitor degradation, the most common single failure by a wide margin - Condenser or blower motor bearing failure - Control board or thermostat failure, especially on ducted multi zone systems - Airflow restriction from filters, crushed ducting or a blocked return - Roof gasket compression loss, which leaks water into the coach - A cracked or UV embrittled shroud letting rain into the condenser section ## Water at the ceiling, replacement, and cost A rooftop unit sits on a foam gasket compressed between the unit base and the roof around a fourteen inch opening. That gasket takes a set over time, and when it stops sealing, water enters at the ceiling assembly and runs along the roof structure. Owners often read this as a roof leak, and functionally it is one. Regasketing is a modest job when the roof structure around the opening is sound. When we open one and the decking around the cutout reads wet, that becomes roof work first, because bolting a unit down onto soft decking produces a unit that loosens and leaks again within a year. Diagnosis is the in depth diagnostic tier at one hour and $285, credited against an authorized repair, with labor at the posted mechanical and electrical rate of $260 per hour across 2 to 14 hours. A capacitor is near the bottom of the band. A complete unit replacement with a new gasket, a ceiling assembly and thermostat integration is at the top, at 7 to 25 business days for the unit. Where hail or a struck branch damaged the shroud or the coil, that is frequently a claim and we document it that way. ## Not included - Refrigerant recovery and charging require EPA Section 608 certification. An uncertified technician cannot legally perform it. - Chassis dash air conditioning is engine driven and is truck shop work rather than coach work. - We do not service rooftop units at a customer location. Roof access is bay work. ## Questions **Can my RV rooftop air conditioner be recharged?** Almost never, because these are sealed systems with no service ports. They are not built to be recharged in the field. Separately, any work that recovers or adds refrigerant requires EPA Section 608 certification by federal law and cannot legally be done without it. A unit that has genuinely lost its charge gets replaced, and that is the equipment design rather than an upsell. **Why is my RV air conditioner blowing warm air?** In order of likelihood: a failed run capacitor so the compressor never starts, a dragging or seized fan motor, a control board or thermostat fault, or an airflow restriction. Airflow surprises people, because a mechanically healthy unit with a clogged filter or a crushed duct simply cannot cool. Capacitors are inexpensive and they are the first thing we read. **Why does my AC ice up?** Usually airflow, not refrigerant. When too little warm air passes over the evaporator, the coil drops below freezing and condensation turns to ice, which then blocks airflow completely. Dirty filters, a crushed duct, or a return path blocked by an interior modification are the common causes. Running on a very cool thermostat setting in humid weather contributes. **Water is dripping from my ceiling AC assembly. Is that the roof?** Functionally yes. A rooftop unit seals to the roof with a foam gasket compressed around a fourteen inch opening, and that gasket takes a set over the years. When it stops sealing, water enters at the ceiling assembly. Regasketing is modest work if the decking around the opening is sound. If it reads wet, the roof gets addressed first. --- Source: https://ocrv.club/rv-service/air-conditioner-repair-and-replacement OCRV Center, 23281 La Palma Ave, Yorba Linda, CA 92887 Phone (949) 799-3387. Email info@ocrvcenter.com. Serving Hacienda Heights and the surrounding area. 18.4 miles, 24 to 38 minutes via SR-60 west to Fullerton Rd, then south to La Palma Ave. In shop work only. All estimates are priced and credited against an authorized repair.